Down4Sound

DOWN4SOUND | D4S LTO 6.0 - 12V Lithium Battery ( 3000 - 5000W )

(109 reviews) Write a Review
SKU:
d4s-lto-6.0
MPN:
lto 6.0
  • Down4Sound DOWN4SOUND or D4S LTO 6.0 - 12V Lithium Battery 3000 - 5000W
  • Down4Sound DOWN4SOUND or D4S LTO 6.0 - 12V Lithium Battery 3000 - 5000W
  • Down4Sound DOWN4SOUND or D4S LTO 6.0 - 12V Lithium Battery 3000 - 5000W
  • Down4Sound DOWN4SOUND or D4S LTO 6.0 - 12V Lithium Battery 3000 - 5000W
MSRP: $599.99
$399.00
— You save $200.99

Description

D4S 12 Volt  LITHIUM BATTERY DETAILS ( PLEASE READ THIS ENTIRE DESCRIPTION FROM START TO FINISH FOR BEST RESULTS WITH THIS BATTERY )

You’re looking at the first ever DOWN4SOUND lithium battery! We are super excited to bring the smallest, yet most powerful lithium battery to date, in car audio! Pairing a super small footprint with tons of output makes it a win-win! For all features and specifications on why the Down4Sound LTO-6.0 should be your ONLY CHOICE for your next lithium purchase, please read more about this GAME CHANGER below.

Model - LTO-6.0

cells capable of 40C, rated for 20C daily use to maintain 12v+

Designed to work directly inline with stock charging voltages (No voltage-boosting needed to achieve optimal results).

Can be paired with regular 12v / non-lithium batteries with no issues.

14.8v Maximum Charge voltage (DO NOT EXCEED THIS OR BATTERY DAMAGE / FAILURE COULD OCCUR).

DO NOT MOUNT UNDER THE HOOD UNDER ANY CIRCUMSTANCES AS SEVERE DAMAGE / FAILURE COULD OCCUR.

Wattage Range - 3000-5000W (Depends largely on alternator input).

Example -
120-160A alternator - 3000w rating
240-270A alternator - 4000w rating
320-370A alternator - 5000w rating

CRAZY RECHARGE RATE (can take a High-Output alternator by itself with NO ISSUES).

6 Ah
70 Wh

Battery Technology - LTO (Lithium Titanate Oxide).
*We feel this is the safest lithium technology.

Built-in Balancing (No other parts or assembly needed).

Comes with conventional M6 terminals for ease of installation.

DO NOT OVER-TIGHTEN BATTERY TERMINALS!
Whether using the automotive post adapters, bolts or screws, the tightening torque should never exceed
6 ft-lbs MAX on any Down4Sound battery!
 
USE TERMINAL BLOCKS WHEN USING IN HIGH CURRENT APPLICATION
When connecting to this battery a solid, low resistance connection is suggested. Because of the high
output of this battery, excessive heat can develop on and around the terminals that can cause damage
to the battery housing. Do not apply an excessive load if using steel posts or other high resistance
materials to connect to this battery. 1/O gauge cable or larger is recommended for all connections


Lightweight & compact design

Weight - 4 pounds! YES, YOU READ THAT RIGHT! FOUR POUNDS!
Measurements
Width - 7”
Height - 4.75”
Depth - 3.5”

PROPER CHARGING IS CRUCIAL!
 
Charge before initial use, be sure to read the instruction sheet for full instructions proper charging is
crucial to the life of your Down4Sound battery. It is very important that the temperature of the battery
remains cool with respect to the charge voltage.
 
CHARGING
Typically the battery will ship at less than 100% State of Charge (SOC.) Please charge your new battery immediately upon receipt. For charging your 12V Lithium battery we recommend a battery charger specifically designed for lithium batteries Lithium batteries are by their very nature voltage sensitive. Further, the lithium battery is the most vulnerable to damage while charging. It is important that the charging process of the battery be fully understood and carefully controlled. Do not use a battery charger designed for “Flooded” or “Maintenance Free” batteries. Do not use a battery charger with a “de-sulfa-tion mode” or “float mode”. USING THIS STYLE OF CHARGER WILL CAUSE DAMAGE / FAILURE AND VOID WARRANTY. Remove the battery charger once the battery is full meaning 100% State of Charge. Unlike lead acid batteries, over charging lithium batteries does not help them nor cause them to store more power. Instead it harms them and should be strictly avoided. Lithium cells are in a state of stress when at 100% SoC and beyond. Continuous charging must be avoided. Lithium batteries do not have a “memory effect” therefore they do not have to be empty to benefit from re-charging. Simply recharge them when convenient and avoid overcharging. In general,float charging or battery maintain-ing should be avoided. Can be charged at a rate of 60A continuous, 400A 10 sec
If you want to charge this battery with a battery charger, it MUST BE A LITHIUM BATTERY CHARGER such as https://www.down4soundshop.com/down4sound-d4s-chg-15a-12v-lithium-charger/

(Using a regular battery charger can damage the battery / void the warranty).

STATE OF CHARGE

100% - 13.6V

96% - 13.2V

77% - 12.8V

54% - 12.4V

25% - 12V

10% - 11.6V 

8% - 11.2V

5% - 10.8V

1% - 10.4V

0% - 10V


Warranty: 1 year from date of purchase against manufacture defects.

TIPS LIST
Read the battery label and do not exceed any of the ratings. Do not over discharge this battery. Terminal
voltage should at all times remain above 10V. Disconnect when not in use. Make sure you have the
correct charger. Lithium batteries are voltage sensitive so pay close attention to the max voltage rating.
Do not use an undersized battery for the job esp. in applications under 32F. If the terminal voltage
under load drops below 10V the battery is too small for the job. Stop and resolve this issue before
continuing. Pulse loads by their very nature are a pseudo short circuit of the battery. This is fundamentally
destructive to the battery so each battery’s State of Health should be regularly checked. 
 
INSTALLATION
You may mount the lithium battery in any direction as long as it is secured from short circuits and/or movement. One word of caution though. This battery is very light and therefore it does not require a great deal of force to hold it. Do not crush the battery with battery retention systems. The threads are M6-1.0. Optional mounting kits and terminals are available. Observe the maximum torque ratings on the battery label Be extremely careful when making connections. Remember there is no low voltage disconnect, reverse polarity, or short circuit protection on the main terminals of this battery. Further the power output of a lithium battery is four times that of typical lead acid batteries. Short circuits will flow huge amounts of current instantly with the ability to melt metal.Do not expose to temperatures above 60oC (140oF). Avoid mounting this battery in the engine compartment if at all possible. Elevated temperatures accelerate the aging process of most battery types and lithium batteries are especially sensitive to high temperatures. Open circuit voltage should be above 12V,  when fully charged after resting for 8 hours. If it is less than this after resting for 8 hours, the battery should be taken out of service and must be checked for capacity, cell balance, and State of Health before resuming operation.
 
USAGE
In general the lithium battery will outperform the lead acid battery it is replacing. If it does not, chances are you have a battery that is too small for the job. Stop now, take it out and return it for the correctly sized model. In general pulling the battery’s terminal voltage below 10V  for even the shortest amount of time is asking for a premature failure. This must be avoided. Lithium batteries have a relatively flat discharge curve when compared to a lead acid battery. The good news is that the average terminal voltage throughout discharge will be 12.5V for 12V models. Unfortunately this can make judging the state of charge difficult when the battery is near empty. Lithium batteries at a low state of charge will still show a relatively high voltage. It is important to get to know the limits of your battery because over discharge below 10V  must be strictly avoided.
 
WARNINGS
To reduce the risk of fire or personal injury including burns: - Do not over charge the battery (meaning exceed the maximum voltage OR amperage and remove the    charger once the battery is at 100% SOC.).
- Do not short circuit the terminals.
- Use with alternators requires that the charging voltage be limited to 14.4V or less. 13.8~14.0 is    preferred for 12V models.
- Do not charge this battery if the terminal voltage is below 10V.
- Contact Down4Sound for assistance before proceeding.
- Avoid high temperature. Never operate the battery in environments above 130oF or if the battery itself    exceeds 130oF at any point.
- Lithium batteries contain flammable gases. Have a plan in place to respond to possible fire. Installation    inside of metal enclosures is recommended in the event of fire.
- Disconnect the battery in total before welding anywhere on the vehicle.
Do not submerse in water. This battery is not waterproof.
- Do not crush, puncture, or dispose in fire or water.
- Do not attempt to open, disassemble, or service the battery pack
 

TESTING

LTO 6.0 Standalone Testing Notes:  

SPL TESTING SECTION. BURPS. STANDALONE. (Wattage verified with termlab)

 

1,000W. 12.93 to 12.85. Immediate recovery. 

 

2,000W. 12.93 to 12.4. 

 

5,000W. 12.93 to 12.05. 

 

8,000w. 12.91 to 11.12. 

 

8,300w. 14.1 to 11.4. 

 

After the 8,300w burp, battery recovered to 12.8. A 25a lithium charger was applied. 1m 4s later, battery was floating at 14.5. 

 

Battery stud temp raised 4*, and casing raised 2-3*. 

 

****ENGINE TURNOVER TESTING SECTION***

 

4 CYLINDER TURBO TEST

*first crank* 12.8 to 11.96. 

 

Next test:

Vehicle accessory mode for 5 minutes, then start: 

5 minutes with head lights on.  Engine still started fine. Dropped to 10.9. Quickly back up on a stock charge system. 

 

Next test:

Brutal engine cranking (simulating super cold temps where engine needs numerous cranks to start). 

3 engine cranks in a row. 5 seconds on then turn the engine off. 5 seconds later, start again. Starting at 12.9. Dropped to 11.4 on the last of 3 starts. Same test with an AGM (D5100) Dropped to 10.9. 

 

NO STUD OR BATTERY TEMP DIFFERENCE DURING THIS TEST WAS OBSERVED. 

—————————————————————

6 CYLINDER TEST

 

12.9 to 11.77. Battery was above 14v with stock charging in 20 seconds. No lag noticed or difficulty starting. 

 

3 start roulette placed battery in upper 10’s. Same test as performed above. 

 

NO STUD OR BATTERY TEMP DIFFERENCE DURING THIS TEST WAS OBSERVED. 

 

—————————————————————

 

8 CYLINDER TEST (V8 mustang. Naturally aspirated) 

 

12.9 to 11.4. Battery was above 14v with stock charging in 45 seconds. No lag noticed or difficulty starting. 

 

3 start roulette battery seen 10.9 at the last run. 

 

NO STUD OR BATTERY TEMP DIFFERENCE DURING THIS TEST WAS OBSERVED. 

 

—————————————————————

DIESEL ENGINE (POWERSTROKE)

 

 

12.9 to 10.9. Battery was above 14v with stock charging in 1 minute. No lag noticed or difficulty starting. 

 

Ignition problems in vehicle prevented 3 start roulette. 

 

NO STUD OR BATTERY TEMP DIFFERENCE DURING THIS TEST WAS OBSERVED. 

—————————————————————

View AllClose

Warranty Information

Warranty Information

Your new Down4Sound product is covered by 1 limited warranty if purchased from Down4Sound or an authorized Down4Sound dealer. This warranty does not cover improper installation, accidental damage, misuse, abuse, improper wiring, operation of unit outside of listed specifications, or any product that has been modified or repaired by anyone other than Down4Sound. Your warranty covers defects in materials and/or workmanship ONLY and is not an insurance policy. The warranty only covers the original owner of the amplifier.

All warranty returns must be accompanied by the original sales invoice or receipt. You must contact us to request an RMA number prior to sending any returns via the RMA request form on our website. You are responsible for the cost of shipping your product back to us for warranty examination. If your product is covered under warranty, shipping back to you will be at no charge to you – if your product is replaced/repaired outside of warranty you must pay for return shipping and repair bill prior returning of the product or if no defect is found you are required to pay for return shipping only.

At the sole discretion of Down4Sound your product will be either repaired or replaced when it is being covered under warranty. In the event of shipping damage due to improper packaging on products being returned to Down4Sound the customer is liable for the cost of all damages, necessary repairs, or replacement. Be sure to properly pack your return!

*  Extended additional warranty purchased on amplifiers take in affect from the date of purchase and must also be stated on orginal sales invoice or receipt. 

 

 

Refund/Return Policy: https://www.down4soundshop.com/shipping-returns/

 

Down4Sound - Hours of Operation

Monday 6am - 9pm PDT
Tuesday 6am - 9pm PDT
Wednesday 6am - 9pm PDT
Thursday 6am - 9pm PDT
Friday 6am - 9pm PDT
Saturday 8am - 4pm PDT
Sunday Closed
View AllClose

109 Reviews

  • 5

    D4S LTO 6.0

    Posted by RalphG on Feb 07, 2023

    Great product, got one after watching a lot of their YouTube videos and product reviews. Would definitely buy again and recommend. Thx D4S

  • 5

    Mind blown!!

    Posted by Rick Abrams on Jan 21, 2023

    Been looking at the 6.0 since they came out. And i am completly happy with it. It blows my mind that a battery the size of a lawn mower batt packs so much power! I added it to the Xs power agms and superbank and it now holds 14.4 plus at full tilt! My truck now maintains 14.8 with the alt hot.. Before with just the agms i would pull it down to mid 13s full tilt . I purchased just one to see how it would do. I will be ordering two more ASAP!! If you are looking for big power in a small foot print and budget friendly i highly recommend the 6.0!! My resting voltage was 12.9 before and now rests at 13.2 !! Cannot wait to add two or more to have that rock solid voltage in my daily driver!!!

  • 5

    D4S LTO 6.0

    Posted by Tim Scott on Jan 14, 2023

    A little pricey but for the size and the amount of power it gives I think it’s worth it. I have 2 of them in the back and I never see below 13v at full tilt running 2 Skar skv2-1500 strapped with 2 Skar zvx12” subs and a Skar skv2-3500 with 2 more Skar zvx12” subs.

  • 4

    Can't Wait......

    Posted by John Box on Jan 11, 2023

    My name is John and here is my story.... I am working on my audio build for my 2014 Charger, and I already have the 4-channel amp, mono amp, sound deadening mats, high output alternator 330A, 10-inch 4-ohm sub (because I need to keep as much trunk space as possible but like cone area) and I need a few more things before everything are installed. As I was going down my requirement list, I found that I was in the need for a lithium battery source. With multiple research "avenues", I came across some YouTube videos about Mr. Price's DOWN4SOUND | D4S LTO 6.0 - 12V Lithium Battery. So, I decided to bite the bullet and purchased it and to my surprise, it was beyond small. I know Mr. Price held it in his hand, but I was thinking that there were "camera lighting" tricks, but it's legit!! This battery is crazy small and will fit anywhere. I haven't had it installed yet because I haven't had it charged up, because I have to buy the power supply charger for it. I have already taken about 4 pictures of it with my cellphone, and I didn't know how to post pictures on this review because I didn't see an attachment option to do so. To those on the fence, do your research and then add to cart if it meets your battery needs. For me, I will be pushing between 1800-3500 watts, (depending on how I load the sub ohms, so this is perfect for me! Thank you Down4sound for all of the forms of financing also!!

  • 5

    Powerhouse!

    Posted by Cody Kern on Jan 08, 2023

    Having lights dimming? Voltage gauge dropping? Don’t want to worry about balancing or if getting lithium will be compatible with your current battery? This LTO 6.0 is perfect and super easy to install worry free! Added this to my XS AGM and my voltage is solid! I just wish I had another one is the only problem:) thanks D4S love your products!

  • 5

    D4S Lithium Battery

    Posted by AGMA on Jan 04, 2023

    Just bought these bad boys recently, very compact, perfect for my future build I can't wait to finish it, Thanks D4S Team for the awesome service and support, I'm very happy definitely buying from here in the future.

  • 5

    This battery is incredible

    Posted by Matthew on Jan 02, 2023

    D4S has been with me since I got into SPL and have always had the best customer service. They have everything you need. With that being said, READ THE DESCRIPTION AND DO YOUR RESEARCH ON BATTERY CHEMISTRY…. And you can achieve amazing things. Even with stock charging systems! Just do it right! This battery will eliminate almost any and all resistance with amps ranging from 1500-5000 watts, upgrade to 4g or bigger and multiple runs, big 3/4 (the more appropriate grounds the better). Stock alt will absolutely pound a 3k amp at 1 ohm with multiple runs of power and ground while cruising. Just don’t skimp on your upgrades. Educate yourself and hustle hard. I intend to buy a 2nd LTO 6.0 and gain match a 2nd amp to power dual 15s. I can easily double my wattage with a few feet of cable, another amp, and a 2nd LTO 6.0. Taking my RMS from 3500 to 7000… think about that

  • 5

    This battery is incredible

    Posted by Matthew on Jan 02, 2023

    D4S has been with me since I got into SPL and have always had the best customer service. They have everything you need. With that being said, READ THE DESCRIPTION AND DO YOUR RESEARCH ON BATTERY CHEMISTRY…. And you can achieve amazing things. Even with stock charging systems! Just do it right! This battery will eliminate almost any and all resistance with amps ranging from 1500-5000 watts, upgrade to 4g or bigger and multiple runs, big 3/4 (the more appropriate grounds the better). Stock alt will absolutely pound a 3k amp at 1 ohm with multiple runs of power and ground while cruising. Just don’t skimp on your upgrades. Educate yourself and hustle hard. I intend to buy a 2nd LTO 6.0 and gain match a 2nd amp to power dual 15s. I can easily double my wattage with a few feet of cable, another amp, and a 2nd LTO 6.0. Taking my RMS from 3500 to 7000… think about that

  • 5

    XSpower D3400, JSPower alt, and a LTO6.0

    Posted by robert oshir on Dec 28, 2022

    I’m very satisfied with the voltage support and recharge rate has done to my system. I am planning on running several of these, and if your running a lot of amperage pull, I suggest upgrading with more than 1 battery and getting a combo pack.

  • 5

    D4s lithium battery

    Posted by Crecenciano sanchez on Dec 02, 2022

    I'm happy with the product.. just missing the t shirt.

View AllClose

Related Products

Related Products